CB Micro-Carbon II Series Filter Cartridges product photo Primary L

CB Micro-Carbon II Series Filter Cartridges

High Efficiency Carbon Block Filtration

  • Economical alternative to granular activated carbon cartridges
  • High porosity design maximizes utilization of carbon to prevent premature plugging
  • Proprietary manufacturing process yields a filter with greater dirt-holding capacity
  • DOE end configuration
  • Absorbs oil vapor

High Efficiency Carbon Block Filtration

  • Economical alternative to granular activated carbon cartridges
  • High porosity design maximizes utilization of carbon to prevent premature plugging
  • Proprietary manufacturing process yields a filter with greater dirt-holding capacity
  • DOE end configuration
  • Absorbs oil vapor


Download Datasheet
Description

High Efficiency Carbon Block Filtration

  • Economical alternative to granular activated carbon cartridges
  • High porosity design maximizes utilization of carbon to prevent premature plugging
  • Proprietary manufacturing process yields a filter with greater dirt-holding capacity
  • DOE end configuration
  • Absorbs oil vapor

High Efficiency Carbon Block Filtration

  • Economical alternative to granular activated carbon cartridges
  • High porosity design maximizes utilization of carbon to prevent premature plugging
  • Proprietary manufacturing process yields a filter with greater dirt-holding capacity
  • DOE end configuration
  • Absorbs oil vapor
Applications
 
 OrganicsTaste, Odor, ColorChlorineParticulate Removal
Water
DrinkingXXXX
UtilitiesXXXX
Chemicals
Single PassXX X
Recirculating   Use pre-filter
 
WARNING: Do not use with water that is microbiologically unsafe or of unknown quality without adequate disinfection before or after the system.

NOTE: These cartridges contain a very small amount of carbon fines (very fine black powder). After installation, flush the cartridge for a minimum of 5 minutes to remove all traces of the fines before using the water. You should run (flush) the tap at least 20 seconds prior to using water for drinking or cooking purposes. This is particularly important if the tap has not been used daily.

CAUTION: Filter must be protected against freezing, which can cause cracking of the filter and water leakage.
Performance

Filter grade1

  • 5 μm

Initial Δ P @ flow rate

  • 24.8 cm (9.75 in.), 25.4 cm (10 in.): .07 bard @ 3.8 lpm (0.95 psid @ 1 gpm)
  • 50.8 cm (20 in.): .06 bard @ 7.6 lpm (0.85 psid @ 2 gpm)

Chlorine reduction @ flow rate2

  • 24.8 cm (9.75 in.), 25.4 cm (10 in.): >22,713 liters @ 3.8 lpm (>6,000 gallons @ 1 gpm)
  • 50.8 cm (20 in.): >45,425 liters @ 7.6 lpm (>12,000 gallons @ 2 gpm)

Maximum operating temperature

  • 82.2 °C (180 °F)

Food and water contact use

Please contact Pall Corporation to verify that the product conforms to your national legislation and/or regional regulatory requirements for water and food contact use.

Liquid Flow Rate vs. Differential Pressure5

Liquid Flow Rate vs. Differential Pressure

1 Micron rating based on 85% or greater removal of a given particle size. Data obtained from actual particle counts using AC Fine Test Dust.
2 Chlorine reduction data is for 2 ppm free chlorine to <0.5 ppm.
5 Flow rate is for a 25.4 cm (10 in) cartridge. For liquids other than water, multiply differential pressure by fluid viscosity (cP). Unit conversion: 1 bar=100 kPa.
Ordering Information
Pall Part Number = C [1] P – CB5

Table 1

 
CodeCartridge lengths cm/in. (nominal)
9.7524.8/9.75
1025.4/10
2050.8/20
3076.2/30
 

Materials of construction

  • Filter media: Bonded porous activated carbon with polyethylene binders3
  • End caps: Polypropylene
  • Inner/outer wraps: Polypropylene
  • Netting: Polyethylene
  • Gaskets: Santoprene4

Dimensions (nominal)

  • Outside diameter: 6.9 cm (2.7 in.)
  • Inner diameter: 2.5 cm (1 in.)
  • Lengths: 24.8 cm (9.75 in.), 25.4 cm (10 in.), 50.8 cm (20 in.), 76.2 cm (30 in.)

3 Take binders into consideration when determining chemical compatibility.
4 Registered trademark of Advanced Elastomer Systems.
Segment
Cartridge Filters